歐亞服務熱線
<table id="1bt6a"></table>
歐亞服務熱線歐亞服務熱線//0752-2618996
| 地址: | 惠州市仲愷高新區惠環 |
| 街道西坑工業區 | |
| 電話: | 0752-2618999 |
| 0752-2618996 | |
| 傳真: | 0752-2618995 |
| 網站: | www.dev-desk.com |
| 郵箱: | ye168@eurasia.net.cn |
產品名稱：EUK抗污涂料
產品價格：面議
產品規格：4L,20L
產品數量：現貨
所屬類別：3C家電涂料篇
生產廠商：惠州市歐亞涂料有限公司
產品性能測試：
Product performance test:
|
測試項目
TEST ITEM
|
測試方法
TEST CONDITION
|
|
|
附著性
Crosshatch adhesion
|
1mm2方格100個，透明膠帶測試
A grid of 100 squares (1mm2), peeled with a pressure sensitive tape.
|
100/100 |
|
鉛筆硬度 Pencil hardness |
三菱2H鉛筆500g力 MITSUBISHI 2H 500gf |
OK |
|
耐磨性 Abrasion resistance |
RCA測試法175gf RCA 175gf |
300次無露底
300 time No visible substrate beneath the coating |
|
震動耐磨 Vibration and abrasion resistance |
2小時 2hours |
OK |
|
記號筆測試 Marking pen test |
真彩記號筆劃5個位置長35mm左右墨條，觀察油墨收縮狀況和樣板對比 Draw line with length about 35mm by true color marking pen at five positions, observe printing ink contraction and compare it with the sample |
OK |
|
耐醇性 Alcohol resistance |
995% alcohol, W=9.8N（1kgf）Rubbing for 50 time. 99.5%酒精W=9.8N（1kgf）來回擦拭，露底前回數。 |
≥100回
≥100 time
|
|
耐濕熱 Humidity resistance |
40℃x 98%RH x 48H |
無異狀
No change
|
|
耐高低溫循環性 Heat-and-Cold cycle |
(-20℃x8h ? 60℃x8h ) x 10 循環 (-20℃x8h ? 60℃x8h ) x 10 cycle |
無異狀
No change
|
|
耐高溫 High temperature test |
85℃x85RH x 48h
|
無異狀
No change
|
|
耐低溫 Low temperature test |
-25℃x96h |
無異狀
No change
|
|
接觸角測試 Contact angle test |
a)接觸角測量儀；
a) Contact angle meter
b)容量為0.1ml的針管，滴水針頭內徑0.2mm；
b) Needle tubing with volume of 0.1ml and the pinhead with inner diameter of 0.2mm;
c)測試液體：蒸餾水、正十六烷；（測試水滴為針頭外徑的2～3倍）
c) Test liquid: distilled water, n-hexadecane (test water drop is 2 to 3 times as large as outer diameter of pinhead)
|
水滴角≧110度;
油滴角≧65度
Angle of water drop ≧ 110°;
Angle of oil drop ≧ 65°
|
測試條件：
Preparation of test panels:
1.噴涂底材：ABS塑膠板
1. Substrate: ABS plastic plates
2.前處理：用清潔劑擦拭面油污及塵粒
2. Surface pretreatment: Removing grease and dust, with detergent.
3.漆膜厚度：20～25ｕｍ （空氣噴涂）
3. Film thickness: 20~25μm（air spray coating）.
4.預干燥：60℃ X 5min+UV800～1000mg/cm2
4. Pre-drying: 60℃ X 5min+UV800～1000mg/cm2
注意事項：
Notes:
1、涂料應密封貯存于陰涼處，防水、防曬、防高溫、遠離火源。
1. Sealed and stored in the dry and cool environment. Kept away from water , sunshine, high-temperature and fire.
2、涂料在室溫下不開罐的貯存期為半年。
2. Storage period of coating is half a year in room temperature under tank sealing condition.
3、底漆在各自工藝條件下完全固化后方可使用該涂料。依據不同的底漆或基材附著不好的現象可能發生，使用前請確認。
3. The primer must be cured thoroughly before application of UV coatings, otherwise the poor adhesion may occur.
4、使用前請用400目的濾網過濾。
4. Filtered with 400# silk gauze before use.
5、涂料光固化前要有足夠的溫度和時間預烘干，否則會影響到漆膜性能。
5. The UV coatings must have enough pre-drying before UV curing, otherwise the film properties may be influenced.
版權所有©2016 惠州市歐亞涂料有限公司 
粵ICP備16065135號-1
地址：惠州市仲愷高新區惠環街道西坑工業區 技術支持：網聯科技
電話：0752-2618999 2618996 傳真：0752-2618995
